Skip to main content
Download PDF

Lead remediation by geological fluorapatite combined with Penicillium Oxalicum and Red yeast

Microbial Cell Factories volume 23, Article number: 64 (2024) Cite this article

Abstract

Phosphate solubilizing fungi Penicillium oxalicum (POX) and Red yeast Rhodotorula mucilaginosa (Rho) have been applied in Pb remediation with the combination of fluorapatite (FAp), respectively. The secretion of oxalic acid by POX and the production of extracellular polymers (EPS) by Rho dominate the Pb remediation. In this study, the potential of Pb remediation by the fungal combined system (POX and Rho) with FAp was investigated. After six days of incubation, the combination of POX and Rho showed the highest Pb remove ratio (99.7%) and the lowest TCLP-Pb concentration (2.9 mg/L). The EPS combined with POX also enhanced Pb remediation, which has a 99.3% Pb removal ratio and 5.5 mg/L TCLP-Pb concentration. Meanwhile, Rho and EPS can also stimulate POX to secrete more oxalic acid, which reached 1510.1 and 1450.6 mg/L in six days, respectively. The secreted oxalic acid can promote FAp dissolution and the formation of lead oxalate and pyromorphite. Meanwhile, the EPS produced by Rho can combine with Pb to form EPS-Pb. In the combined system of POX + Rho and POX + EPS, all of the lead oxalate, pyromorphite, and EPS-Pb were observed. Our findings suggest that the combined application of POX and Rho with FAp is an effective approach for enhancing Pb remediation.

Introduction

Lead (Pb) contamination is a widespread environmental issue that has garnered global attention [1, 2]. Unlike organic pollutants, Pb contamination persists in the environment without degrading over time [3]. The input pathway of Pb into the environment includes wastewater discharge, fossil fuel combustion, metal mining, and other human activities [4]. More importantly, the excessive Pb would threaten water security, causing various physical ailments such as anemia, encephalopathy, hepatitis, nephrotic syndrome, etc. [5, 6]. Therefore, the remediation of lead pollution needs to be highly valued.

Apatite has been successfully applied for heavy metal remediation in soil and water, especially for Pb contaminates [7, 8]. Fluorapatite (FAp) is the most abundant apatite in the Earth’s crust [9, 10]. The phosphorus (P) contained in FAp can react with Pb to form highly insoluble Pb minerals pyromorphite [Pb5(PO4)3F] [9, 10]. The formed pyromorphite (Pyro) mineral is highly stable and can lock the Pb cations in complex environments [10]. However, the low solubility of most apatites limits their application in Pb remediation [10, 11].

Phosphate solubilizing fungi (PSF) can enhance the efficiency of Pb remediation by apatite [10]. Combining PSF and apatite can significantly improve the Pb remove ratio (95%~99%) [10]. On the one hand, PSF usually has a high ability to secrete organic acids, such as oxalic acid, citric acid, etc. [12]. These organic acids can promote the release of P from apatite and react with Pb to form insoluble pyromorphite [11, 13,14,15]. For example, PSF-Aspergillus niger can secrete 2400 mg/L oxalic acid and promote 370 mg/L P release from fluorapatite, removing more than 99% of Pb cations via the form of Pyro [10]. On the other hand, the secreted oxalic acid by PSF can also react with Pb to form insoluble lead oxalate (LO) [10, 11]. Therefore, combining PSF and apatite is an efficient pathway in Pb remediation.

Like PSF, Red yeast has also been used in Pb remediation. As a widely occurring fungus, Red yeast has a strong growth rate and environmental resistance in wastewater environments [16]. However, Red yeast immobilizes Pb primarily by producing extracellular polymeric substances (EPS) [15, 17]. The produced EPS can react with Pb cations to generate EPS-Pb and reduce the toxicity of Pb [18]. In addition, adding apatite can promote EPS production by Red yeast and remove more than 98% of lead cations [19]. More importantly, EPS also contains large amounts of organic components, such as hydroxyl and carboxyl, which function in heavy metal cation chelation and supply nutrients for the growth of other microorganisms [20, 21].

Penicillium oxalicum (POX) and Red yeast-Rhodotorula mucilaginosa (Rho) are capable of surviving and maintaining their metabolite production ability under a high Pb concentration, i.e., 1000 mg/L and 2500 mg/L, respectively [11, 18]. Consequently, these two fungi have been utilized in remediating environments with high Pb levels, especially in the combination of phosphate [19, 22]. Furthermore, the high production of EPS by Rho suggests a collaborative effect between POX and Rho in Pb remediation. The combination of Rho could potentially enhance the Pb remediation by POX. However, the full potential of this combined fungal system, i.e., POX and Rho, for Pb remediation remains to be elucidated.

This study explored the Pb remediation by the combined fungal system (POX and Rho) with fluorapatite. The concentrations of P and Pb in the medium were analyzed by inductively coupled plasma optical emission spectrum (ICP-OES). Meanwhile, the toxicity characteristic leaching procedure of Pb (TCLP-Pb) in precipitates was also analyzed by ICP-OES. High-performance liquid chromatography (HPLC) was used to analyze the secretion of organic acids. The composition of precipitates was analyzed by X-ray diffraction (XRD). Rho and P. oxalicum morphology and mineral composition were observed using a scanning electron microscope–energy dispersive spectrometer (SEM-EDS).

Materials and methods

Strains incubation

P. oxalicum (POX) was isolated from maize rhizosphere soil in the Northern Anhui Experimental Station, Suzhou City, Anhui Province, China (Fig. S1). The collected fungi were stored in the China General Microbiological Culture Collection Center (CGMCC No. 22,475). Before the incubation, 200 g of potato was cut into small pieces and boiled with sterile water for 20 min. After filtration with four-layer sterile gauze, the filtrate was collected and mixed with 20 g agar and 20 g dextrose into a 1000 mL solution. Then, the PDA medium was separately transferred to a 250 mL conical flask and sterilized for the next experiment for 20 min at 121 oC. P. oxalicum was cultured in potato dextrose agar medium (PDA) at 28 oC for five days and then drenched with sterile water to obtain the spores. Then, mycelium fragments were filtered with four layers of sterilized cheesecloth to obtain the spore suspensions [23].

Red yeast-Rhodotorula mucilaginosa (Rho) (Fig. S1) was received from the China General Microbiological Culture Collection Center (CGMCC No. 16,597). Before the experiment, Rho was inoculated to a potato dextrose broth (PDB) medium (sterilized at 121oC for 20 min)and shaken for 48 h at 28 oC, 180 rpm [15]. The preparation of the PDB medium had the same process as the PDA without agar.

Apatite preparation

Fluorapatite (FAp) was collected from Kaiyang Phosphate Rock Reserve in Guizhou Province (N 27° 6′ 50″, E 106° 51′ 5″), China. All the FAp samples were ground to powder, dried, and filtered by 100 mesh.

The extraction of extracellular secretions of Rho

Firstly, the incubated Rho was collected and centrifuged twice at 12,000 rpm for 20 min at 4 °C. Then, the collected Rho supernatant was added to a 3-fold volume of anhydrous ethanol. Thirdly, the mixture was allowed to rest for 48 h at 4 °C to collect extracellular secretions (EPS) and supernatant fluid (SFU). The crude extractants were transferred into 3500 molecular-weight dialysis bags and immersed in pure water for 72 h. The water was changed twice every 24 h. Finally, the extractants were moved into a 2 mL centrifuge tube for the next experiment [18].

Pb remediation by P. oxalicum and Rho with FAp

The Pb contamination in water was prepared by Pb(NO3)2 powder (Xilong Scientific Ltd.). The initial Pb concentration in the medium was adjusted to 1500 mg/L. Six treatments were performed in this experiment, i.e., POX (P. oxalicum) + FAp, Rho + FAp, POX + Rho + FAp, POX + EPS + FAp, POX + SFU + FAp, FAp. Before the incubation, the 0.24 g Pb(NO3)2 powder and 1.0 g FAp powder were added to 250 mL Erlenmeyer flasks with 100 mL PDB medium (sterilized at 121oC for 20 min) in a sterile environment, respectively. Then, the 1.0 mL spore suspension (P. oxalicum and Rho), 1.0 mL SFU, and 1.0 g EPS were added to the corresponding treatment, respectively (Fig. S2). Each treatment was performed with four replicates. After sealing with parafilm (BS-QM-003, Biosharp), the flasks were incubated at 180 rpm, 28 oC in a sterile condition. After incubation for six days, the PDB medium was filtered into 50 mL centrifugal tubes with phosphorus-free filter paper and centrifuged for 6 min at 5000 rpm. Then, the supernatant liquid was filtered through a 0.45 μm polyethersulfone (PES) membrane. The filtrates were tested for pH value, P and Pb content, and organic acids. The centrifugal precipitates were collected and dried at 55 oC for 24 h to obtain the biomass, TCLP-Pb, XRD, and SEM analysis.

TCLP-Pb extraction from precipitates

The toxicity characteristic leaching procedure (TCLP) method was used to extract the Pb from the precipitates. 2.0 g precipitates and 40mL extraction agent (select extractant 1 when pH < 5, select extractant 2 when pH > 5) were mixed and shaken at 180 rpm, for (18 ± 2) h. After centrifuge and filtering, the TCLP-Pb concentration in the precipitate was determined using ICP-OES [24]. This experiment used extraction agent 1 (pH < 5) to extract the TCLP-Pb. Extractant 1: Dissolve 5.7mL of glacial acetic acid in 500mL of deionized water, then add 1 mol/L of NaOH 64.3 ml, and bring the volume to 1 L. Adjust the pH of the solution using 1 mol/L of HNO3 or 1 mol/L of NaOH to maintain it within the range of 4.93 ± 0.05 [25,26,27].

Instrumentation

The pH value in each treatment was measured using a pH meter (Mettler Toledo Int. Inc.). The soluble P and Pb concentrations were analyzed via ICP-OES (PerkinElmer Avio 710). The P and Pb calibration standards concentrations were 2, 5, 10, 20, 50 mg/L, and 10, 50, 100, 200, and 500 mg/L. The R square value of the external standard curve was 0.999 [28].

The contents of the organic acids were determined by high-performance liquid chromatography (HPLC) (Agilent 1200) with a column temperature of 30 °C. Then, the standard oxalic acid solution was prepared and diluted into 1000, 500, 100, 50, 20, and 10 mg/L, respectively. The R square value of the internal standard curve was 0.999 [29].

The mineralogical characterization of the precipitates was examined by Rigaku D/Max-2500 X-ray diffraction (Cu-Kα; 36 kV; 20 mA; scanned from 5° to 60° at a speed of 4° s− 1). The XRD patterns were analyzed by MDI Jade 6.5 software for phase identification.

The morphology of Rho and minerals was observed by SEM (S4800 Hitachi) with an acceleration voltage of 3 kV. The samples were coated with a layer of gold for 1 min in Hitachi E-1010 Sputter to enhance image quality.

Results

pH and dry biomass in medium

The initial pH in the medium was 5.7. After six days of incubation, the pH value in all treatments was decreased to 3.5–3.8 (Fig. 1A). In the POX + FAp and Rho + FAp treatments, the pH dropped to 3.5 and 4.4 (Fig. 1A). In POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp, the pH value was 3.8, 3.9, and 3.5 after six days of incubation, respectively (Fig. 1A). The pH in FAp treatment also decreased to 4.8 (Fig. 1A).

Fig. 1
figure 1

The pH value (A) and dry biomass (B) in each treatment after six days of incubation. The error bars represent the standard deviations of four replicates. The significant differences among the treatments were identified by Tukey’s honestly significant difference test (p < 0.05) via one-way ANOVA. Rho: Rhodotorula mucilaginosa; POX: P. oxlaicum

Full size image

In POX + FAp, Rho + FAp, and FAp treatments, the dry biomass was 1.9 g, 1.8 g, and 1.2 g after six days of incubation, respectively (Fig. 1B). In POX + EPS + FAp and POX + SFU + FAp treatments, the dry biomass after six days of incubation was 2.9 g, and 2.4 g, respectively (Fig. 1B). The POX + Rho + FAp treatment had the highest dry biomass compared with other treatments, reached to 3.1 g after six days of incubation (Fig. 1B).

P concentration and oxalic acid concentration

After six days of incubation, POX + Rho + FAp and POX + EPS + FAp treatments had a high P concentration, i.e., 16.1 and 14.2 mg/L, respectively (Fig. 2A). In POX + FAp, Rho + FAp, and POX + SFU + FAp treatments, the P concentration had no significant difference, i.e., 8.3, 6.1, and 6.9 mg/L, respectively (Fig. 2A). In FAp treatment, the P concentration had the lowest value of 1.3 mg/L (Fig. 2A).

Fig. 2
figure 2

The P concentration (A) and oxalic acid (B) concentration in each treatment after six days of incubation. The error bars represent the standard deviations of four replicates. The significant differences among the treatments were identified by Tukey’s honestly significant difference test (p < 0.05) via one-way ANOVA. Rho: Rhodotorula mucilaginosa; POX: P. oxlaicum

Full size image

Oxalic acid is the primary organic acid in each treatment. In POX + Rho + FAp and POX + EPS + FAp treatments, the oxalic acid concentration had the highest value of 1510.1 and 1450.6 mg/L at six days, respectively (Fig. 2B). The oxalic acid concentration in POX + FAp and POX + SFU + FAp treatments was 446.6 and 581.8 mg/L after six days of incubation (Fig. 2B). In Rho + FAp and FAp treatment, the oxalic acid almost undetectable after six days of incubation, i.e., 24.6 and 18.4 mg/L (Fig. 2B).

Pb, TCLP-Pb concentration, and pb remove ratio

The initial Pb concentration in the PDB medium was 1500 mg/L. After six days of incubation, the Pb concentration in POX + Rho + FAp and POX + EPS + FAp treatments decreased to the lowest value of 4.7 and 9.8 mg/L (Fig. 3A). In POX + FAp, Rho + FAp, and POX + SFU + FAp treatments, the Pb concentration decreased to 78.5, 27.4 and 88.5 mg/L, respectively (Fig. 3A). However, the Pb concentration in FAp treatment had the highest value of 430.1 mg/L after six days of incubation (Fig. 3A). The TCLP-Pb concentration from precipitates in each treatment was significantly lower than Pb concentration in the medium. After six days of incubation, the TCLP-Pb concentration in POX + Rho + FAp and POX + EPS + FAp treatments was only 2.9 and 5.5 mg/L (Fig. 3A). In POX + FAp, Rho + FAp, and POX + SFU + FAp treatments, the TCLP-Pb concentration was 15.7, 30.1, and 12.9 mg/L, respectively (Fig. 3A). Similarly, the TCLP-Pb in FAp treatment also had the highest value of 257.3 mg/L (Fig. 3A).

Fig. 3
figure 3

The Pb and TCLP-Pb concentration (A) and Pb remove ratio (B) in each treatment after six days of incubation. The error bars represent the standard deviations of four replicates. The significant differences among the treatments were identified by Tukey’s honestly significant difference test (p < 0.05) via one-way ANOVA. Rho: Rhodotorula mucilaginosa; POX: P. oxlaicum

Full size image

The Pb removal ratio in POX + FAp, Rho + FAp, POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp treatments had a close value of 95.6%, 98.2%, 99.7%, 99.3%, and 94.1%, respectively (Fig. 3B). In FAp treatment, the Pb remove ratio had the highest value of 71.3% after six days of incubation (Fig. 3B). That is to say, more than ~ 1000 mg/L Pb was removed from the medium to the precipitates in each treatment. However, the stable capacity of removed Pb in each treatment was different. The TCLP-Pb/removed Pb ratio had the lowest value in POX + Rho + FAp and POX + EPS + FAp treatments, i.e., 0.19% and 0.37% (Fig. 3B). In POX + FAp, Rho + FAp, and POX + SFU + FAp treatments, the TCLP-Pb/removed Pb ratio was 1.10%, 2.04%, and 0.91%, respectively (Fig. 3B). In FAp treatment, the TCLP-Pb/removed Pb ratio had the highest value of 24.05% (Fig. 3B).

XRD analysis

Figure 4 shows the XRD patterns of precipitates in each treatment after six days of incubation. The peak of FAp (31.94°, 32.27°, and 33.12°) and Cerussite (24.8° and 25.49°) were observed in each treatment (Fig. 4). The peak located at 29.68° stand for lead oxalate mineral was detected in POX + FAp, POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp treatments (Fig. 4). In addition, the peaks of pyromorphite (Pyro) (30.74° and 30.84°) also appeared in POX + FAp, POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp treatments (Fig. 4).

Fig. 4
figure 4

XRD patterns of precipitation in each treatment after six days of incubation

Full size image

Full width at half maxima (FWHM) value and peak area ratio

The FWHM value in POX + FAp, POX + Rho + FAp, POX + EPS + FAp, POX + SFU + FAp, and FAp treatments was 0.333, 0.324, 0.329, 0.330, 0.329 and 0.319 after six days of incubation, respectively (Fig. 5A). The peak area ratio of LO/FAp in POX + FAp, POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp treatments was 0.376, 0.175, 0.179, and 0.085 after six days of incubation, respectively (Fig. 5B). The peak area ratio of Pyro/FAp in POX + FAp had the highest value of 0.060 (Fig. 5B). In POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp treatments, the Pyro/FAp peak area ratio was 0.043, 0.061, and 0.025 after six days of incubation, respectively (Fig. 5B).

Fig. 5
figure 5

The FWHM value of FAp (A) and peak value ratio of LO/FAp and Pyro/FAp (B) in each treatment after six days of incubation. FAp: fluorapatite, LO: lead oxalate, Pyro: pyromorphite

Full size image

SEM-EDS analysis

The SEM-EDS images of fungi and mineral morphologies are shown in Fig. 6. The spores and hypha of P. oxalicum can be observed in the treatment with adding POX (Fig. 6). Meanwhile, the Rho was also observed in POX + Rho + FAp treatment and had a significant size than P. oxalicum spores (Fig. 6C). In each treatment, the mineral of FAp can be observed with a large size (Fig. 6). The mineral of LO can also be observed in POX + Rho + FAp, POX + EPS + FAp, and POX + SFU + FAp treatments (Fig. 6). Large amounts of EPS-Pb was observed in Rho + FAP treatment (Fig. 6B). In POX + EPS + FAp treatment, both of LO and EPS-Pb were observed (Fig. 6D).

Fig. 6
figure 6

SEM images and EDS point data in POX + FAp (A), Rho + FAp (B), POX + Rho + FAp (C), POX + EPS + FAp (D), POX + SFU + FAp (E), FAP (F) treatments after six days of incubation. The symbols (a,b,c,d,e,f) stand for the point area of EDS analysis in each treatment. LO: lead oxalate, FAp: fluorapatite, Rho: Rhodotorula mucilaginosa

Full size image

Discussion

Apatite is an efficient material in Pb remediation due to its ability to reduce the bioavailability of Pb through mineralization and adsorption [30]. For example, using crystallite-size apatite (200 × 40 nm) can immobilize Pb by forming a pyromorphite mineral [31]. Meanwhile, the apatite can also adsorb ~ 0.16 mmol Pb/g in an aqueous solution [32]. However, the mineral pyromorphite is challenging to form due to the low solubility of FAp [33]. Our results indicate that only 71.3% of Pb cations (1069 mg/L) were removed by only FAp, with more than 430 mg/L Pb cations also remaining in the solution (Fig. 3). Additionally, these removed Pb cations were unstable and could be released again in an acidic environment. The TCLP-Pb results indicated that ~ 24.1% Pb (257.3 mg/L) cations are released from the removed Pb (1069 mg/L) (Fig. 3). Therefore, using FAp in Pb remediation needs further reinforcement, especially in phosphorus release and Pb minerals formation.

The application of fungi of P. oxalicum and Rho can promote Pb remediation by FAp [14, 15, 34]. Compared to using FAp alone, the combination of P. oxalicum and Rho increased the Pb remove ratio to 95.6% and 98.2%, respectively (Fig. 3). This Pb remove ratio is similar to the previous research, i.e., ~ 98% Pb remove ratio by P. oxalicum and Rho with phosphate [19, 22]. Meanwhile, P. oxalicum and Rho can survive under the 1500 mg/L Pb concentration [19, 22]. The hypha and spores can be observed in SEM images in each treatment (Fig. 6). In addition, the Pb cations immobilization in P. oxalicum and FAp combination system is via the formation of pyromorphite and lead oxalate, while in Rho and FAp is primarily through the formation of EPS-Pb. The XRD and SEM-EDS results can also indicate the production form of removed Pb cations (Figs. 4 and 6). Therefore, the results suggest that the Pb remediation pathways between P. oxalicum and Rho with FAp are different.

The different secondary metabolites between P. oxalicum and Rho decide the final form of removed Pb cations. Like other PSFs, P. oxalicum can secrete large amounts of organic acid, especially oxalic acid, which is the primary organic acid secreted by these fungi [23, 35]. Oxalic acid not only promotes the release of P in FAp to form pyromorphite (Pyro) but also can directly combine Pb to form insoluble lead oxalate (LO) [10, 36,37,38]. The XRD results also indicate the formation of LO and Pyro (Fig. 4). Meanwhile, both LO and Pyro are stable and have a low Ksp value (~ 10− 11 and ~ 10− 85) [10, 22]. Hence, only 1.1% of Pb cations (TCLP-Pb) can be released from removed Pb in POX + FAp treatment (Fig. 3B). Unlike P. oxalicum, Rho with FAp in Pb immobilization is primary through the production of EPS rather than the dissolution of FAp [19]. In Rho + FAp treatment, the FWHM value of FAp is lower than POX + FAp treatment, which could indicate the weakly dissolution of FAp. The SEM images also confirmed the production of EPS and the formation of large amounts of EPS-Pb (Fig. 6B). EPS has strong binding and adsorption ability for metal cations due to its complex functional groups [39]. More importantly, adding phosphate can increase Rho’s production of EPS [19]. Meanwhile, the EPS is more efficient in binding with heavy metal cations (e.g., Cu2+ and Pb2+) [40, 41]. Therefore, Rho is more efficient than P. oxalicum in Pb remediation. Our results also confirmed that the Pb remove ratio in Rho + FAp is higher than POX + FAp, i.e., 98.2% vs. 95.6% (Fig. 3B).

Compared with P. oxalicum and Rho, the combined fungal system (P. oxalicum + Rho) is more efficient in Pb remediation by FAp. Our results indicate that POX + Rho + FAp has the highest Pb remove ratio (99.7%) and the lowest TCLP-Pb concentration (Fig. 3). Rho can promote Pb remediation by P. oxalicum through the secretion of EPS. It has a similar Pb remove ratio (99.7% and 99.3%) and TCLP-Pb concentration (2.9 and 5.5 mg/L) between POX + Rho and POX + EPS treatment (Fig. 3). On the one hand, EPS has an complex mixture of multiple biomolecules (proteins, polysaccharides, humic-like substances, uronic acid, nucleic acid, lipids and glycoproteins) [15, 42, 43]. These biomolecules can promote the secretion of oxalic acid by P. oxalicum (Fig. 2B). The secreted oxalic acid can react with Pb to form lead oxalate and promote FAp transfer to pyromorphite [22]. The analysis of LO/FAp and Pyro/FAp peak area ratio in POX + Rho + FAp and POX + EPS + FAp are higher than in POX + SFU + FAp treatment (no EPS) (Fig. 5). Therefore, Rho combined with PSF that have higher oxalic acid secretion ability (e.g., Aspergillus niger) could be more effective in Pb remediation by FAp [23, 35]. On the other hand, the EPS has a complex molecular composition, so it has strong adsorption and combining capacity to lead cations and can react with Pb to form a stable EPS-Pb [18, 44, 45]. The formed EPS-Pb reduced the Pb toxicity and promoted the growth of P. oxalicum (Fig. 1B). Studies have pointed out that proteins and polysaccharides in EPS are the main factors of resistance to heavy metals [42, 46]. These organic components have highly branched chemical structures and functional groups, such as hydroxyl and carboxyl [44, 45]. This spatial structure and complex composition allow it to adsorb and chelate with Pb2+, thereby reducing the toxicity of heavy metals [15].

Conclusion

PSF P. oxalicum and Red yeast Rho combined with FAp can significantly promote the Pb remediation and maintain the stability of removed Pb cations. Oxalic acid secreted by P. oxalicum not only promotes P release from FAp to form pyromorphite but also reacts with Pb to form insoluble lead oxalate. EPS dominates the Pb remediation by Rho via the formation of stable EPS-Pb. More importantly, the secreted EPS by Rho can promote the growth of P. oxalicum and increase the secretion of oxalic acid. The combination of P. oxalicum and Rho is the most effective pathway in Pb remediation by FAp.

Data availability

The publication includes a list of all the datasets used in this investigation.

Abbreviations

POX:

Penicillium oxalicum

Rho:

Rhodotorula mucilaginosa

EPS:

extracellular polymers

FAp:

fluorapatite

TCLP-Pb:

toxicity characteristic leaching procedure of Pb

PSF:

phosphate solubilizing fungi

LO:

lead oxalate

SFU:

supernatant fluid

PDB:

potato dextrose broth

Pyro:

pyromorphite

References

  1. Hou D, Qi S, Zhao B, Rigby M, O’Connor D. Incorporating life cycle assessment with health risk assessment to select the ‘greenest’ cleanup level for pb contaminated soil. J Clean Prod. 2017;162:1157–68.

    Article  CAS  Google Scholar 

  2. Gadd G. Interactions of fungi with toxic metals. New Phytol. 1993;124:25–60.

    Article  CAS  Google Scholar 

  3. Rhee Y, Hillier S, Gadd G. Lead transformation to pyromorphite by fungi. Curr Biol. 2012;22(3):237–41.

    Article  CAS  PubMed  Google Scholar 

  4. Cao X, Wahbi A, Ma L, Li B, Yang Y. Immobilization of Zn, Cu, and pb in contaminated soils using phosphate rock and phosphoric acid. J Hazard Mater. 2009;164(2–3):555–64.

    Article  CAS  PubMed  Google Scholar 

  5. Dutta SK, Singh D, Sood A. Effect of Soil Chemical and physical properties on sorption and desorption behavior of lead in different soils of India. Soil Sediment Contam. 2011;20(3):249–60.

    Article  CAS  Google Scholar 

  6. Martins BL, Cruz CCV, Luna AS, Henriques CA. Sorption and desorption of Pb2+ ions by dead Sargassum sp. biomass. Biochem Eng J. 2006;27:310–4.

    Article  CAS  Google Scholar 

  7. Wang YM, Chen TC, Yeh K. Stabilization of an elevated heavy metal contaminated site. J Hazard Mater. 2001;88(1):p63–74.

    Article  Google Scholar 

  8. Li Z, Tang L, Zheng Y, Tian D, Su M, Zhang F, Ma S, Hu S. Characterizing the mechanisms of lead immobilization via bioapatite and various clay minerals. ACS Earth Space Chem. 2017;1:152–7.

    Article  ADS  CAS  Google Scholar 

  9. Ma QY, Traina SJ, Logan TJ, Ryan JA. In situ lead immobilization by apatite. Environ Sci Technol. 1993;27(9):1803–10.

    Article  ADS  CAS  Google Scholar 

  10. Li Z, Wang F, Bai T, Tao J, Guo J, Yang M, Wang S, Hu S. Lead immobilization by geological fluorapatite and fungus aspergillus Niger. J Hazard Mater. 2016;320:386–92.

    Article  CAS  PubMed  Google Scholar 

  11. Tian D, Jiang. Z, Jiang L, Su M, Feng Z, Zhang L, Wang S, Li Z, Hu S. A new insight into lead (II) tolerance of environmental fungi based on a study of Aspergillus Niger and Penicillium Oxalicum. Environ Microbiol. 2019;21(1):471–9.

    Article  CAS  PubMed  Google Scholar 

  12. Li Z, Bai TS, Dai LT, Wang FW, Tao JJ, Meng ST, Hu YX, Wang SM, Hu SJ. A study of organic acid production in contrasts between two phosphate solubilizing fungi: Penicillium Oxalicum and Aspergillus Niger. Sci Rep. 2016, 6.

  13. Coutinho FP, Felix WP, Yano-Melo AM. Solubilization of phosphates in vitro by Aspergillus spp. and Penicillium spp. Ecol Eng. 2012;42:85–9.

    Article  Google Scholar 

  14. Frisvad JC, Møller L, Larsen TO, Kumar R, Arnau J. Safety of the fungal workhorses of industrial biotechnology: update on the mycotoxin and secondary metabolite potential of aspergillus Niger, aspergillus oryzae, and Trichoderma reesei. Appl Microbiol Biot. 2018;42:85–9.

    Google Scholar 

  15. Li J, Jiang Z, Chen S, Wang T, Jiang L, Wang M, Wang S, Li Z. Biochemical changes of polysaccharides and proteins within EPS under Pb(II) stress in Rhodotorula mucilaginosa. Ecotox Environ Safe. 2019;174:484–90.

    Article  CAS  Google Scholar 

  16. Gientka I, Blazejak S, Stasiak-Rozanska L, Chlebowska-Smigiel A. Exopolysaccharides from yeast: insight into optimal conditions for biosynthesis, chemical composition and functional properties - review. Acta Sci Pol Technol Aliment. 2015;14(4):283–92.

    Article  CAS  PubMed  Google Scholar 

  17. Pagliaccia B, Carretti E, Severi M, Berti D, Lubello C, Lotti T. Heavy metal biosorption by extracellular polymeric substances (EPS) recovered from anammox granular sludge. J Hazard Mater. 2022;424:126661.

    Article  CAS  PubMed  Google Scholar 

  18. Jiang Z, Wang T, Sun Y, Nong Y, Tang L, Gu T, Wang S, Li Z. Application of pb(II) to probe the physiological responses of fungal intracellular vesicles. Ecotoxicol Environ Safe. 2020;194:110441.

    Article  CAS  Google Scholar 

  19. Tian D, Cheng X, Wang L, Hu J, Zhou N, Xia J, Xu M, Zhang L, Gao H, Ye X et al. Remediation of lead-contaminated water by red yeast and different types of phosphate. Front Bioeng Biotech. 2022, 10.

  20. Kot AM, Blazejak S, Kieliszek M, Gientka I, Brys J, Reczek L, Pobiega K. Effect of exogenous stress factors on the biosynthesis of carotenoids and lipids by Rhodotorula yeast strains in media containing agro-industrial waste. World J Microbiol Biotechnol. 2019;35(10):157.

    Article  PubMed  PubMed Central  Google Scholar 

  21. Rahbar Saadat Y, Yari Khosroushahi A, Pourghassem Gargari B. Yeast exopolysaccharides and their physiological functions. Folia Microbiol. 2021;66(2):171–82.

    Article  CAS  Google Scholar 

  22. Tian D, Wang W, Su M, Zheng J, Wu Y, Wang S, Li Z, Hu S. Remediation of lead-contaminated water by geological fluorapatite and fungus penicillium oxalicum. Environ Sci Pollut Res. 2018;25:21118–26.

    Article  CAS  Google Scholar 

  23. Tian D, Wang L, Hu J, Zhang L, Zhou N, Xia J, Xu M, Yusef KK, Wang S, Li Z, et al. A study of P release from Fe-P and Ca-P via the organic acids secreted by Aspergillus Niger. J Microbiol. 2021;59(9):819–26.

    Article  CAS  PubMed  Google Scholar 

  24. Halim CE, Amal R, Beydoun D, Scott JA, Low G. Evaluating the applicability of a modified toxicity characteristic leaching procedure (TCLP) for the classification of cementitious wastes containing lead and cadmium. J Hazard Mater. 2003;103(1–2):125–40.

    Article  CAS  PubMed  Google Scholar 

  25. Chen QY, Yang L, Liu L, Qian LW, Tian KL, Zhang Q, Cao DJ. Combined forms of pb and its detoxification and absorption in Cladophora rupestris subcells. Spectrochim Acta Mol Biomol Spectrosc. 2021;248:119190.

    Article  CAS  Google Scholar 

  26. Wan J, Zhang C, Zeng G, Huang D, Hu L, Huang C, Wu H, Wang L. Synthesis and evaluation of a new class of stabilized nano-chlorapatite for pb immobilization in sediment. J Hazard Mater. 2016;320:278–88.

    Article  CAS  PubMed  Google Scholar 

  27. Dursun AY, Uslu G, Cuci Y, Aksu Z. Bioaccumulation of copper(II), lead(II) and chromium(VI) by growing aspergillus Niger. Process Biochem. 2003;38(12):1647–51.

    Article  CAS  Google Scholar 

  28. Tian D, Su M, Zou X, Zhang L, Tang L, Geng Y, Qiu J, Wang S, Gao H, Li Z. Influences of phosphate addition on fungal weathering of carbonate in the red soil from karst region. Sci Total Environ. 2020;755:142570.

    Article  ADS  PubMed  Google Scholar 

  29. Feng Y, Zhang L, Li X, Wang L, Yusef KK, Gao H, Tian D. Remediation of lead contamination by aspergillus Niger and Phosphate Rocks under different Nitrogen sources. Agronomy. 2022, 12(7).

  30. Giammar DE, Xie LY, Pasteris JD. Immobilization of lead with nanocrystalline carbonated apatite present in fish bone. Environ Eng Sci. 2008;25(5):725–35.

    Article  CAS  Google Scholar 

  31. Kamiishi E, Utsunomiya S. Nano-scale reaction processes at the interface between apatite and aqueous lead. Chem Geol. 2013;340:121–30.

    Article  ADS  CAS  Google Scholar 

  32. Radoicic TK, Raicevic S. In situ lead stabilization using natural and synthetic apatite. Chem Ind Chem Eng Q. 2008;14(4):269–71.

    Article  CAS  Google Scholar 

  33. Chen W, Wang Q, Meng S, Yang P, Jiang L, Zou X, Li Z, Hu S. Temperature-related changes of ca and P release in synthesized hydroxylapatite, geological fluorapatite, and bone bioapatite. Chem Geol. 2017;451:183–8.

    Article  ADS  CAS  Google Scholar 

  34. Jiang G, Liu Y, Huang L, Fu Q, Deng Y, Hu H. Mechanism of lead immobilization by oxalic acid-activated phosphate rocks. J Environ Sci. 2012;24(5):919–25.

    Article  CAS  Google Scholar 

  35. Tian D, Zhang X, Wang L, Han M, Zhang C, Ye X. Lead remediation is promoted by phosphate-solubilizing fungi and apatite via the enhanced production of organic acid. Front Bioeng Biotechnol. 2023;11:1180431.

    Article  PubMed  PubMed Central  Google Scholar 

  36. Elliott JC. Calcium phosphate biominerals. Rev Mineral Geochem. 2002;48(1):427–53.

    Article  CAS  Google Scholar 

  37. Strasser H, Burgstaller W, Letters FS. High-yield production of oxalic acid for metal leaching processes by Aspergillus Niger. FEMS Microbiol Lett. 1994;119(3):365–70.

    Article  CAS  PubMed  Google Scholar 

  38. Tian D, Xia J, Zhou N, Xu M, Li X, Zhang L, Du S, Gao H. The utilization of Phosphogypsum as a sustainable phosphate-based fertilizer by Aspergillus Niger. Agronomy 2022, 12(3).

  39. Duda-Chodak A, Tarko T, Milotta K. Applicability of DifferentKinds of Yeast Biomass to lead removal from Water. J Elemntol. 2012;17:7–18.

    Google Scholar 

  40. Naveed S, Li C, Lu X, Chen S, Yin B, Zhang C, Ge Y. Microalgal extracellular polymeric substances and their interactions with metal(loid)s: a review. Crit Rev Environ Sci Technol. 2019;49(19):1769–802.

    Article  CAS  Google Scholar 

  41. Yan P, Xia JS, Chen YP, Liu ZP, Guo JS, Shen Y, Zhang CC, Wang J. Thermodynamics of binding interactions between extracellular polymeric substances and heavy metals by isothermal titration microcalorimetry. Bioresour Technol. 2017;232:354–63.

    Article  CAS  PubMed  Google Scholar 

  42. Guibaud G, Bhatia D, ’Abzac PD, Bourven I, Bordas F, Hullebusch E, Lens P. Cd(II) and pb(II) sorption by extracellular polymeric substances (EPS) extracted from anaerobic granular biofilms: evidence of a pH sorption-edge. J Taiwan Inst Chem E. 2012;43(3):444–9.

    Article  CAS  Google Scholar 

  43. Ian WS. The biofilm matrix – an immobilized but dynamic microbial environment. Trends Microbiol. 2001;9:222–7.

    Article  Google Scholar 

  44. Kot AM, Baejak S, Kieliszek M, Gientka I, Bry J. Simultaneous Production of Lipids and carotenoids by the red yeast Rhodotorula from Waste glycerol fraction and Potato Wastewater. Appl Biochem Biotech. 2019;189(2):589–607.

    Article  CAS  Google Scholar 

  45. Saadat YR, Khosroushahi AY, Gargari BP. Yeast exopolysaccharides and their physiological functions. Folia Microbiol. 2021;66(2):171–82.

    Article  Google Scholar 

  46. Alvarez, Pedro J, Qu J, Xiaolei, Kang, Fuxing, Zhu, Science DJE, et al. Extracellular saccharide-mediated reduction of Au3 + to gold nanoparticles: New insights for Heavy metals Biomineralization on Microbial surfaces. Environ Sci Technol. 2017;51(5):2776–85.

    Article  PubMed  Google Scholar 

Download references

Acknowledgements

We appreciate Yang Xu from the Biotechnology Center of Anhui Agricultural University for the technical support of SEM in this study. We thank Zhen Li from Nanjing Agricultural University for the supply of the Red yeast strain.

Funding

This work was supported by the National Natural Science Foundation of China (NO. 42007030), the Natural Science Foundation of Anhui Province (NO. 2008085QD187), the Program at the Department of Natural Resources of Anhui Province (NO. 2021-K-11) and the Program at Anhui Agricultural University (NO. yj2019-20).

Author information

Author notes

  1. Qiang Guan and Xiaohui Cheng contributed equally to this work and share the first authorship.

Authors and Affiliations

  1. Ministry of Ecology and Environment Peoples Republic of China, Nanjing Institute of Environmental Science, No. 8, Jiangwang Miao Street, Nanjing, 210042, China

    Qiang Guan, Yue He, Yifan Yan, Lei Zhang & Zhan Wang

  2. Anhui Province Key Lab of Farmland Ecological Conservation and Nutrient Utilization, Anhui Province Engineering and Technology Research Center of Intelligent Manufacture and Efficient Utilization of Green Phosphorus Fertilizer, College of Resources and Environment, Anhui Agricultural University, Hefei, 230036, P. R. China

    Xiaohui Cheng, Liangliang Zhang & Da Tian

  3. Key Laboratory of JiangHuai Arable Land Resources Protection and Eco-restoration, Ministry of Natural Resources, College of Resources and Environment, Anhui Agricultural University, Hefei, Anhui, 230036, P. R. China

    Xiaohui Cheng, Liangliang Zhang & Da Tian

Authors
  1. Qiang Guan
    View author publications

    You can also search for this author in PubMed Google Scholar

  2. Xiaohui Cheng
    View author publications

    You can also search for this author in PubMed Google Scholar

  3. Yue He
    View author publications

    You can also search for this author in PubMed Google Scholar

  4. Yifan Yan
    View author publications

    You can also search for this author in PubMed Google Scholar

  5. Lei Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

  6. Zhan Wang
    View author publications

    You can also search for this author in PubMed Google Scholar

  7. Liangliang Zhang
    View author publications

    You can also search for this author in PubMed Google Scholar

  8. Da Tian
    View author publications

    You can also search for this author in PubMed Google Scholar

Contributions

All authors contributed to the manuscript revision and approved the submitted version. Conceptualization, L.Z. and D.T.; methodology, Q.G. and X.H.C.; validation, H.Y., Y.F.Y. and Q.G.; formal analysis, Q.G. and X.H.C.; investigation, Z.W. and L.L.Z.; resources, D.T.; data curation, Q.G., X.H.C., Y.F.Y., Z.W. and L.L.Z.; writing—original draft preparation, Q.G., X.H.C., L.Z. and D.T.; writing—review and editing, L.Z. and D.T.; visualization, Q.G., X.H.C. and D.T.; supervision, L.Z. and D.T.

Corresponding authors

Correspondence to Lei Zhang or Da Tian.

Ethics declarations

Competing interests

The authors report no competing interests in this work.

Additional information

Publisher’s Note

Springer Nature remains neutral with regard to jurisdictional claims in published maps and institutional affiliations.

Electronic supplementary material

Below is the link to the electronic supplementary material.

Supplementary Material 1: Additional file 1: Fig. S1.

Phosphate solubilizing fungi Penicillium oxalicum and Red yeast Rhodotorula mucilaginosa were used in this experiment. Fig. S2. The sketch of each treatment in the experiment. Fig. S3. The flask experiment images after six days of incubation.

Rights and permissions

Open Access This article is licensed under a Creative Commons Attribution 4.0 International License, which permits use, sharing, adaptation, distribution and reproduction in any medium or format, as long as you give appropriate credit to the original author(s) and the source, provide a link to the Creative Commons licence, and indicate if changes were made. The images or other third party material in this article are included in the article’s Creative Commons licence, unless indicated otherwise in a credit line to the material. If material is not included in the article’s Creative Commons licence and your intended use is not permitted by statutory regulation or exceeds the permitted use, you will need to obtain permission directly from the copyright holder. To view a copy of this licence, visit http://creativecommons.org/licenses/by/4.0/. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated in a credit line to the data.

Reprints and permissions

About this article

Check for updates. Verify currency and authenticity via CrossMark

Cite this article

Guan, Q., Cheng, X., He, Y. et al. Lead remediation by geological fluorapatite combined with Penicillium Oxalicum and Red yeast. Microb Cell Fact 23, 64 (2024). https://0-doi-org.brum.beds.ac.uk/10.1186/s12934-024-02323-2

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://0-doi-org.brum.beds.ac.uk/10.1186/s12934-024-02323-2

Keywords

Microbial Cell Factories

ISSN: 1475-2859

Contact us